Recommended Suppliersmore
Trichloroacetyl Chloride
CAS No.: 76-02-8
Synonyms:
Formula: C2Cl4O
Exact Mass: 179.87000
Molecular Weight: 181.83300
PSA: 17.07000
LogP: 2.12200
Reference Price: $1,645/ton Inquiry Now
Trichloroacetyl Chloride 76-02-8 MSDS
Name: Trichloroacetyl chloride Material Safety Data Sheet
Synonym: Trichloroacetic acid chloride
CAS: 76-02-8
Section 1 - Chemical Product   MSDS Name:Trichloroacetyl chloride Material Safety Data Sheet
Synonym:Trichloroacetic acid chloride

Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS
CAS# Chemical Name content EINECS#
76-02-8 Trichloroacetyl chloride 97 200-926-7
Hazard Symbols: T+ C
Risk Phrases: 22 26 35

Section 3 - HAZARDS IDENTIFICATION
  EMERGENCY OVERVIEW
Harmful if swallowed. Very toxic by inhalation. Causes severe burns.
Potential Health Effects
Eye:
Causes eye burns. Lachrymator (substance which increases the flow of tears).
Skin:
Causes skin burns.
Ingestion:
Causes gastrointestinal tract burns. May be harmful if swallowed.
Inhalation:
May be fatal if inhaled. Causes chemical burns to the respiratory tract.
Chronic:
Chronic exposure may cause effects similar to those of acute exposure.

Section 4 - FIRST AID MEASURES
  Eyes: In case of contact, immediately flush eyes with plenty of water for at least 15 minutes. Get medical aid immediately.
Skin:
In case of contact, immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Get medical aid immediately. Wash clothing before reuse.
Ingestion:
If swallowed, do NOT induce vomiting. Get medical aid immediately.
If victim is fully conscious, give a cupful of water. Never give anything by mouth to an unconscious person.
Inhalation:
POISON material. If inhaled, get medical aid immediately. Remove victim to fresh air. If not breathing, give artificial respiration.
If breathing is difficult, give oxygen.
Notes to Physician:
Treat symptomatically and supportively.

Section 5 - FIRE FIGHTING MEASURES
  General Information:
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion. Vapors may be heavier than air. They can spread along the ground and collect in low or confined areas. Containers may explode if exposed to fire.
Use of water will produce irritating and toxic vapors of hydrogen chloride. Hydrochloric acid solutions react with most metals, forming flammable hydrogen gas.
Extinguishing Media:
Do NOT use water directly on fire. Use carbon dioxide or dry chemical. Do NOT get water inside containers.

Section 6 - ACCIDENTAL RELEASE MEASURES
  General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Clean up spills immediately, observing precautions in the Protective Equipment section. Provide ventilation. Do not get water inside containers.

Section 7 - HANDLING and STORAGE
  Handling:
Wash thoroughly after handling. Remove contaminated clothing and wash before reuse. Do not get in eyes, on skin, or on clothing. Keep container tightly closed. Do not ingest or inhale. Discard contaminated shoes. Use only with adequate ventilation or respiratory protection.
Storage:
Keep container closed when not in use. Store in a cool, dry, well-ventilated area away from incompatible substances. Corrosives area. Store protected from moisture.

Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
  Engineering Controls:
Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate ventilation to keep airborne concentrations low.
Exposure Limits CAS# 76-02-8: Russia: 0.1 mg/m3 TWA Personal Protective Equipment Eyes: Wear chemical splash goggles.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
A respiratory protection program that meets OSHA's 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use. Wear a NIOSH/MSHA or European Standard EN 149 approved full-facepiece airline respirator in the positive pressure mode with emergency escape provisions.

Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
 
Physical State: Liquid
Color: clear slightly yellow
Odor: None reported.
pH: Not available.
Vapor Pressure: 1.33 hPa @ 51 deg C
Viscosity: Not available.
Boiling Point: 114-116 deg C @ 760 mm Hg
Freezing/Melting Point: -57 deg C
Autoignition Temperature: Not available.
Flash Point: Not available.
Explosion Limits, lower: N/A
Explosion Limits, upper: N/A
Decomposition Temperature:
Solubility in water: decomposes
Specific Gravity/Density: 1.620 g/cm3
Molecular Formula: C2Cl4O
Molecular Weight: 181.83

Section 10 - STABILITY AND REACTIVITY
  Chemical Stability:
Stable under normal temperatures and pressures.
Conditions to Avoid:
Moisture.
Incompatibilities with Other Materials:
Strong oxidizing agents.
Hazardous Decomposition Products:
Hydrogen chloride, phosgene, carbon monoxide, carbon dioxide.
Hazardous Polymerization: Has not been reported.

Section 11 - TOXICOLOGICAL INFORMATION
  RTECS#:
CAS# 76-02-8: AO7140000 LD50/LC50:
CAS# 76-02-8: Inhalation, mouse: LC50 = 445 mg/m3; Inhalation, rat: LC50 = 475 mg/m3/4H; Oral, rat: LD50 = 600 mg/kg.
Carcinogenicity:
Trichloroacetyl chloride - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.

Section 12 - ECOLOGICAL INFORMATION
  Other No information available.

Section 13 - DISPOSAL CONSIDERATIONS
  Dispose of in a manner consistent with federal, state, and local regulations.

Section 14 - TRANSPORT INFORMATION
 
IATA
Shipping Name: TRICHLOROACETYL CHLORIDE
Hazard Class: 8
UN Number: 2442
Packing Group:
IMO
Shipping Name: TRICHLOROACETYL CHLORIDE
Hazard Class: 8
UN Number: 2442
Packing Group: II
RID/ADR
Shipping Name: TRICHLOROACETYL CHLORIDE
Hazard Class: 8
UN Number: 2442
Packing group: II

Section 15 - REGULATORY INFORMATION
 
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: T+ C
Risk Phrases:
R 22 Harmful if swallowed.
R 26 Very toxic by inhalation.
R 35 Causes severe burns.
Safety Phrases:
S 28A After contact with skin, wash immediately with
plenty of water.
S 36/37/39 Wear suitable protective clothing, gloves
and eye/face protection.
S 38 In case of insufficient ventilation, wear
suitable respiratory equipment.
S 45 In case of accident or if you feel unwell, seek
medical advice immediately (show the label where
possible).
WGK (Water Danger/Protection)
CAS# 76-02-8: 2
Canada
CAS# 76-02-8 is listed on Canada's DSL List.
CAS# 76-02-8 is listed on Canada's Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 76-02-8 is listed on the TSCA inventory.


SECTION 16 - ADDITIONAL INFORMATION
N/A

Home   |   Announcement   |   Partners   |   Business Cooperation   |   Suppliers   |   Products    |   About Us   |   Contact Us   |   Privacy Policy   |   Terms & Conditions   |   Legal Statement

Copyright © 2013-2016 MOLBASE All Rights Reserved ICP Shanghai 14014220