1,1-dimethylhydrazine 57-14-7 MSDS
Name: Unsym-Dimethylhydrazine 99% Material Safety Data Sheet
Synonym: 1,1-Dimethylhydrazine; UDM
CAS: 57-14-7
Section 1 - Chemical Product   MSDS Name:Unsym-Dimethylhydrazine 99% Material Safety Data Sheet
Synonym:1,1-Dimethylhydrazine; UDM

Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS
CAS# Chemical Name content EINECS#
57-14-7 Unsym-Dimethylhydrazine 99 200-316-0
Hazard Symbols: T F
Risk Phrases: 11 23/25 34 45

Section 3 - HAZARDS IDENTIFICATION
  EMERGENCY OVERVIEW
Highly flammable. Toxic by inhalation and if swallowed. Causes burns. May cause cancer.Cancer suspect agent.Corrosive.Highly flammable.
Potential Health Effects
Eye:
Causes eye burns. May result in corneal injury.
Skin:
Causes skin burns. May be harmful if absorbed through the skin.
Ingestion:
Harmful if swallowed. May cause severe and permanent damage to the digestive tract. Causes gastrointestinal tract burns. May cause liver damage.
Inhalation:
Harmful if inhaled. Causes chemical burns to the respiratory tract.
Exposure produces central nervous system depression. Vapors may cause dizziness or suffocation.
Chronic:
Possible cancer hazard based on tests with laboratory animals.
Chronic exposure may cause liver damage.

Section 4 - FIRST AID MEASURES
  Eyes: Get medical aid immediately. Do NOT allow victim to rub eyes or keep eyes closed. Extensive irrigation with water is required (at least 30 minutes).
Skin:
Get medical aid immediately. Immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes. Wash clothing before reuse. Destroy contaminated shoes.
Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If not breathing, give artificial respiration. If breathing is difficult, give oxygen. Do NOT use mouth-to-mouth resuscitation.
Notes to Physician:

Section 5 - FIRE FIGHTING MEASURES
  General Information:
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Vapors may form an explosive mixture with air.
Vapors can travel to a source of ignition and flash back. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion. Use water spray to keep fire-exposed containers cool. Containers may explode in the heat of a fire.
Flammable liquid and vapor. Vapors may be heavier than air. They can spread along the ground and collect in low or confined areas.
Will be easily ignited by heat, sparks or flame.
Extinguishing Media:
For small fires, use dry chemical, carbon dioxide, water spray or alcohol-resistant foam. For large fires, use water spray, fog, or alcohol-resistant foam. Use water spray to cool fire-exposed containers. Water may be ineffective. Do NOT use straight streams of water.

Section 6 - ACCIDENTAL RELEASE MEASURES
  General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Clean up spills immediately, observing precautions in the Protective Equipment section. Remove all sources of ignition. Use a spark-proof tool. Provide ventilation. A vapor suppressing foam may be used to reduce vapors.

Section 7 - HANDLING and STORAGE
  Handling:
Wash thoroughly after handling. Use only in a well-ventilated area.
Ground and bond containers when transferring material. Empty containers retain product residue, (liquid and/or vapor), and can be dangerous. Keep container tightly closed. Keep away from heat, sparks and flame. Do not get on skin or in eyes. Avoid ingestion and inhalation. Discard contaminated shoes. Do not pressurize, cut, weld, braze, solder, drill, grind, or expose empty containers to heat, sparks or open flames.
Storage:
Keep away from heat, sparks, and flame. Keep away from sources of ignition. Keep container closed when not in use. Store in a tightly closed container. Store in a cool, dry, well-ventilated area away from incompatible substances. Refrigerator/flammables.

Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
  Engineering Controls:
Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate ventilation to keep airborne concentrations low.
Exposure Limits CAS# 57-14-7: United States OSHA: 0.5 ppm TWA; 1 mg/m3 TWA Belgium - TWA: 0.01 ppm VLE; 0.025 mg/m3 VLE France - VME: 0.1 ppm VME; 0.2 mg/m3 VME Malaysia: 0.01 ppm TWA; 0.25 mg/m3 TWA Spain: 0.01 ppm VLA-ED; 0.025 mg/m3 VLA-ED Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
A respiratory protection program that meets OSHA's 29 CFR 1910.134 and ANSI Z88.2 requirements or European Standard EN 149 must be followed whenever workplace conditions warrant respirator use. Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.

Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
 
Physical State: Liquid
Color: clear light yellow
Odor: fishy ammonical
pH: Strongly alkaline
Vapor Pressure: 145 mbar @ 20 C
Viscosity: 0.56 cP 20.00 deg
Boiling Point: 62.0 - 64.0 deg C @ 753.00mmH
Freezing/Melting Point: -58 deg C
Autoignition Temperature: 249 deg C ( 480.20 deg F)
Flash Point: -17 deg C ( 1.40 deg F)
Explosion Limits, lower: 2.9
Explosion Limits, upper: 95
Decomposition Temperature:
Solubility in water: miscible
Specific Gravity/Density: .7800g/cm3
Molecular Formula: C2H8N2
Molecular Weight: 60.10

Section 10 - STABILITY AND REACTIVITY
  Chemical Stability:
Stable under normal temperatures and pressures.
Conditions to Avoid:
Incompatible materials, ignition sources, dust generation, excess heat.
Incompatibilities with Other Materials:
Halogens, mercury, strong acids, strong oxidizing agents, rubber, plastics.
Hazardous Decomposition Products:
Nitrogen oxides, carbon monoxide, irritating and toxic fumes and gases, carbon dioxide, nitrogen.
Hazardous Polymerization: Has not been reported.

Section 11 - TOXICOLOGICAL INFORMATION
  RTECS#:
CAS# 57-14-7: MV2450000 LD50/LC50:
CAS# 57-14-7: Dermal, guinea pig: LD50 = 1329 mg/kg; Inhalation, mouse: LC50 = 172 ppm/4H; Inhalation, rat: LC50 = 252 ppm/4H; Oral, mouse: LD50 = 155 mg/kg; Oral, rat: LD50 = 122 mg/kg; Skin, rabbit: LD50 = 1060 mg/kg; Skin, rat: LD50 = 770 mg/kg.
Carcinogenicity:
Unsym-Dimethylhydrazine - ACGIH: A3 - Confirmed animal carcinogen with unknown relevance to California: carcinogen, initial date 10/1/89 NTP: Suspect carcinogen IARC: Group 2B carcinogen Other:
See actual entry in RTECS for complete information.

Section 12 - ECOLOGICAL INFORMATION
  Other No information available.

Section 13 - DISPOSAL CONSIDERATIONS
  Dispose of in a manner consistent with federal, state, and local regulations.

Section 14 - TRANSPORT INFORMATION
 
IATA
Shipping Name: DIMETHYLHYDRAZINE, UNSYMMETRICAL
Hazard Class: 6.1 (3)
UN Number: 1163
Packing Group:
IMO
Shipping Name: DIMETHYLHYDRAZINE, UNSYMMETRICAL
Hazard Class: 6.1 (3.2)
UN Number: 1163
Packing Group: I
RID/ADR
Shipping Name: DIMETHYLHYDRAZINE, UNSYMMETRICAL
Hazard Class: 6.1
UN Number: 1163
Packing group: I
USA RQ: CAS# 57-14-7: 10 lb final RQ; 4.54 kg final RQ

Section 15 - REGULATORY INFORMATION
 
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: T F
Risk Phrases:
R 45 May cause cancer.
R 11 Highly flammable.
R 23/25 Toxic by inhalation and if swallowed.
R 34 Causes burns.
Safety Phrases:
S 53 Avoid exposure - obtain special instructions
before use.
S 45 In case of accident or if you feel unwell, seek
medical advice immediately (show the label where
possible).
WGK (Water Danger/Protection)
CAS# 57-14-7: No information available.
Canada
CAS# 57-14-7 is listed on Canada's NDSL List.
CAS# 57-14-7 is listed on Canada's Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 57-14-7 is listed on the TSCA inventory.


SECTION 16 - ADDITIONAL INFORMATION
N/A

Home   |   Announcement   |   Partners   |   Business Cooperation   |   Suppliers   |   Products    |   About Us   |   Contact Us   |   Privacy Policy   |   Terms & Conditions   |   Legal Statement

Copyright © 2013-2016 MOLBASE All Rights Reserved ICP Shanghai 14014220