phenyl carbonochloridate 1885-14-9 MSDS
Name: Phenyl chloroformate 99% (gc) Material Safety Data Sheet
Synonym: Chloroformic Acid Phenyl Ester; Phenyl Chlorocarbonat
CAS: 1885-14-9
Section 1 - Chemical Product   MSDS Name:Phenyl chloroformate 99% (gc) Material Safety Data Sheet
Synonym:Chloroformic Acid Phenyl Ester; Phenyl Chlorocarbonat

Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS
CAS# Chemical Name content EINECS#
1885-14-9 Phenyl chloroformate 97 217-547-8
Hazard Symbols: T+ C
Risk Phrases: 26 34 38

Section 3 - HAZARDS IDENTIFICATION
  EMERGENCY OVERVIEW
Very toxic by inhalation. Causes burns. Irritating to skin.Moisture sensitive.Corrosive.
Potential Health Effects
Eye:
Causes eye burns.
Skin:
Causes skin burns.
Ingestion:
May cause severe and permanent damage to the digestive tract. May be harmful if swallowed. Causes digestive tract irritation with possible burns.
Inhalation:
Causes respiratory tract irritation with possible burns.
Chronic:
No information found.

Section 4 - FIRST AID MEASURES
  Eyes: Flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid immediately. Do NOT allow victim to rub eyes or keep eyes closed.
Extensive irrigation with water is required (at least 30 minutes).
Skin:
Get medical aid immediately. Flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Wash clothing before reuse. Destroy contaminated shoes.
Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately. May cause methemoglobinemia, cyanosis (bluish discoloration of skin due to deficient oxygenation of the blood), convulsions, and death.
Inhalation:
Remove from exposure and move to fresh air immediately. If breathing is difficult, give oxygen. Get medical aid. Do NOT use mouth-to-mouth resuscitation. If breathing has ceased apply artificial respiration using oxygen and a suitable mechanical device such as a bag and a mask.
Notes to Physician:

Section 5 - FIRE FIGHTING MEASURES
  General Information:
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Vapors can travel to a source of ignition and flash back. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion. Use water spray to keep fire-exposed containers cool. Combustible liquid. Vapors may be heavier than air. They can spread along the ground and collect in low or confined areas. Contact with metals may evolve flammable hydrogen gas. Substance may react with water, and may release corrosive and/or toxic gases. Containers may explode when heated.
Extinguishing Media:
For large fires, use water spray, fog, or alcohol-resistant foam. Do NOT use water directly on fire. Use water spray to cool fire-exposed containers. Do NOT use straight streams of water. For small fires, use carbon dioxide, dry chemical, dry sand, or alcohol-resistant foam.

Section 6 - ACCIDENTAL RELEASE MEASURES
  General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Avoid runoff into storm sewers and ditches which lead to waterways.
Clean up spills immediately, observing precautions in the Protective Equipment section. Remove all sources of ignition. Use a spark-proof tool. Provide ventilation. A vapor suppressing foam may be used to reduce vapors. Cover with dry earth, dry sand, or other non-combustible material followed with plastic sheet to minimize spreading and contact with water.

Section 7 - HANDLING and STORAGE
  Handling:
Wash thoroughly after handling. Do not get in eyes, on skin, or on clothing. Empty containers retain product residue, (liquid and/or vapor), and can be dangerous. Keep container tightly closed. Keep away from heat, sparks and flame. Do not ingest or inhale. Use with adequate ventilation. Discard contaminated shoes. Do not pressurize, cut, weld, braze, solder, drill, grind, or expose empty containers to heat, sparks or open flames.
Storage:
Keep away from heat, sparks, and flame. Keep away from sources of ignition. Keep container closed when not in use. Store in a tightly closed container. Store in a cool, dry, well-ventilated area away from incompatible substances. Keep refrigerated. (Store below 4C/39F.)

Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
  Engineering Controls:
Use adequate ventilation to keep airborne concentrations low.
Exposure Limits CAS# 1885-14-9: Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.

Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
 
Physical State: Liquid
Color: clear colorless to faint colored
Odor: None reported.
pH: Not available.
Vapor Pressure: 20 mmHg @ 83 C
Viscosity: Not available.
Boiling Point: 74.0 - 75.0 deg C
Freezing/Melting Point: Not available.
Autoignition Temperature: 560 deg C ( 1,040.00 deg F)
Flash Point: 69 deg C ( 156.20 deg F)
Explosion Limits, lower: Not available.
Explosion Limits, upper: Not available.
Decomposition Temperature:
Solubility in water: decomposes
Specific Gravity/Density: 1.2480g/cm3
Molecular Formula: C7H5ClO2
Molecular Weight: 156.57

Section 10 - STABILITY AND REACTIVITY
  Chemical Stability:
Stable under normal temperatures and pressures. May decompose on exposure to moist air or water.
Conditions to Avoid:
Incompatible materials, ignition sources, moisture, excess heat.
Incompatibilities with Other Materials:
Oxidizing agents, strong bases, bases, alcohols, amines.
Hazardous Decomposition Products:
Hydrogen chloride, phosgene, carbon monoxide, carbon dioxide.
Hazardous Polymerization: Has not been reported.

Section 11 - TOXICOLOGICAL INFORMATION
  RTECS#:
CAS# 1885-14-9: FG3850000 LD50/LC50:
CAS# 1885-14-9: Draize test, rabbit, eye: 50 ug/24H Severe; Draize test, rabbit, skin: 500 mg/24H Mild; Oral, rat: LD50 = 1410 uL/kg; Skin, rabbit: LD50 = 3970 uL/kg.
Oral,Rat: LD50 = 1410 mg/kg mg/kg Carcinogenicity:
Phenyl chloroformate - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.

Section 12 - ECOLOGICAL INFORMATION
 

Section 13 - DISPOSAL CONSIDERATIONS
  Dispose of in a manner consistent with federal, state, and local regulations.

Section 14 - TRANSPORT INFORMATION
 
IATA
Shipping Name: PHENYL CHLOROFORMATE
Hazard Class: 6.1 (8)
UN Number: 2746
Packing Group: II
IMO
Shipping Name: PHENYL CHLOROFORMATE
Hazard Class: 6.1 (8)
UN Number: 2746
Packing Group: II
RID/ADR
Shipping Name: PHENYL CHLOROFORMATE
Hazard Class: 6.1
UN Number: 2746
Packing group: II

Section 15 - REGULATORY INFORMATION
 
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: T+ C
Risk Phrases:
R 26 Very toxic by inhalation.
R 34 Causes burns.
R 38 Irritating to skin.
Safety Phrases:
S 33 Take precautionary measures against static
discharges.
S 45 In case of accident or if you feel unwell, seek
medical advice immediately (show the label where
possible).
WGK (Water Danger/Protection)
CAS# 1885-14-9: 2
Canada
CAS# 1885-14-9 is listed on Canada's DSL List.
CAS# 1885-14-9 is listed on Canada's Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 1885-14-9 is listed on the TSCA inventory.


SECTION 16 - ADDITIONAL INFORMATION
N/A

Home   |   Announcement   |   Partners   |   Business Cooperation   |   Suppliers   |   Products    |   About Us   |   Contact Us   |   Privacy Policy   |   Terms & Conditions   |   Legal Statement

Copyright © 2013-2016 MOLBASE All Rights Reserved ICP Shanghai 14014220