Ethyl vinyl ether 109-92-2 MSDS
Name: Ethyl Vinyl Ether 99% (gc) Material Safety Data Sheet
Synonym: Ethoxy ethene; Vinyl ethyl ethe
CAS: 109-92-2
Section 1 - Chemical Product   MSDS Name:Ethyl Vinyl Ether 99% (gc) Material Safety Data Sheet
Synonym:Ethoxy ethene; Vinyl ethyl ethe

Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS
CAS# Chemical Name content EINECS#
109-92-2 Vinyl ethyl ether 99 203-718-4
Hazard Symbols: F+
Risk Phrases: 11 2 36/37/38

Section 3 - HAZARDS IDENTIFICATION
  EMERGENCY OVERVIEW
Highly flammable. Risk of explosion by shock, friction, fire or other sources of ignition. Irritating to eyes, respiratory system and skin.Lachrymator (substance which increases the flow of tears).Air sensitive.
Potential Health Effects
Eye:
Causes eye irritation. Lachrymator (substance which increases the flow of tears).
Skin:
Causes skin irritation. Prolonged and/or repeated contact may cause defatting of the skin and dermatitis.
Ingestion:
May cause gastrointestinal irritation with nausea, vomiting and diarrhea. May cause central nervous system depression, characterized by excitement, followed by headache, dizziness, drowsiness, and nausea. Advanced stages may cause collapse, unconsciousness, coma and possible death due to respiratory failure.
Inhalation:
Inhalation of high concentrations may cause central nervous system effects characterized by nausea, headache, dizziness, unconsciousness and coma. Causes respiratory tract irritation.
Chronic:
Prolonged or repeated skin contact may cause dermatitis.

Section 4 - FIRST AID MEASURES
  Eyes: Immediately flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid immediately.
Skin:
Get medical aid. Immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Ingestion:
Do not induce vomiting. If victim is conscious and alert, give 2-4 cupfuls of milk or water. Never give anything by mouth to an unconscious person. Get medical aid immediately.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If not breathing, give artificial respiration. If breathing is difficult, give oxygen.
Notes to Physician:

Section 5 - FIRE FIGHTING MEASURES
  General Information:
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. Vapors may form an explosive mixture with air.
Vapors can travel to a source of ignition and flash back. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion. Containers may explode in the heat of a fire. Flammable liquid and vapor. Vapors may be heavier than air.
They can spread along the ground and collect in low or confined areas.
Extinguishing Media:
Use water spray to cool fire-exposed containers. Use foam, dry chemical, or carbon dioxide. Water may be ineffective.

Section 6 - ACCIDENTAL RELEASE MEASURES
  General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Absorb spill with inert material (e.g. vermiculite, sand or earth), then place in suitable container. Wash area with soap and water.
Clean up spills immediately, observing precautions in the Protective Equipment section. Remove all sources of ignition. Use a spark-proof tool. Provide ventilation.

Section 7 - HANDLING and STORAGE
  Handling:
Use spark-proof tools and explosion proof equipment. Avoid breathing dust, vapor, mist, or gas. Avoid contact with eyes, skin, and clothing. Empty containers retain product residue, (liquid and/or vapor), and can be dangerous. Take precautionary measures against static discharges. Keep away from heat, sparks and flame. Avoid ingestion and inhalation. Use only in a chemical fume hood. If peroxide formation is suspected, do not open or move container. Do not pressurize, cut, weld, braze, solder, drill, grind, or expose empty containers to heat, sparks or open flames.
Storage:
Keep away from sources of ignition. Store in a tightly closed container. Store in a cool, dry, well-ventilated area away from incompatible substances. Refrigerator/flammables. Regularly check inhibitor levels to maintain peroxide levels below 1%.

Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
  Engineering Controls:
Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use only under a chemical fume hood.
Exposure Limits CAS# 109-92-2: Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.

Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
 
Physical State: Liquid
Color: clear, colorless
Odor: none reported
pH: Not available.
Vapor Pressure: 428 mm Hg @ 20 deg C
Viscosity: Not available.
Boiling Point: 36 deg C @ 760.00mm Hg
Freezing/Melting Point: -116 deg C
Autoignition Temperature: 180 deg C ( 356.00 deg F)
Flash Point: -50 deg C ( -58.00 deg F)
Explosion Limits, lower: 1.40 vol %
Explosion Limits, upper: 28.00 vol %
Decomposition Temperature:
Solubility in water: Slightly soluble.
Specific Gravity/Density: 0.7540g/cm3
Molecular Formula: C4H8O
Molecular Weight: 72.11

Section 10 - STABILITY AND REACTIVITY
  Chemical Stability:
Not stable during routine use and handling conditions. On long term storage, substances with similar functional groups form explosive peroxides.
Conditions to Avoid:
Incompatible materials, ignition sources, exposure to air.
Incompatibilities with Other Materials:
Oxidizing agents, strong acids, oxygen.
Hazardous Decomposition Products:
Carbon monoxide, carbon dioxide, acrid smoke and fumes.
Hazardous Polymerization: May occur.

Section 11 - TOXICOLOGICAL INFORMATION
  RTECS#:
CAS# 109-92-2: KO0710000 LD50/LC50:
CAS# 109-92-2: Inhalation, mouse: LC50 = 324 gm/m3/15M; Oral, rat: LD50 = 8160 uL/kg; Skin, rabbit: LD50 = >20 mL/kg; Skin, rat: LD50 = >20 gm/kg.
Carcinogenicity:
Vinyl ethyl ether - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.

Section 12 - ECOLOGICAL INFORMATION
  Ecotoxicity:
Fish toxicity: LC50/Leuciscus idus/: >2200 <4600 mg/l/96h Daphnia toxicity: EC/LC50 (48 h):>100 mg/l Algae toxicity: EC/LC50 (72 h): 510 mg/l Bacteriatoxicity: EC/LC50 (17 h): >5000 mg/l

Section 13 - DISPOSAL CONSIDERATIONS
  Dispose of in a manner consistent with federal, state, and local regulations.

Section 14 - TRANSPORT INFORMATION
 
IATA
Not regulated as a hazardous material.
IMO
Not regulated as a hazardous material.
RID/ADR
Not regulated as a hazardous material.

Section 15 - REGULATORY INFORMATION
 
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: F+
Risk Phrases:
R 11 Highly flammable.
R 2 Risk of explosion by shock, friction, fire or
other sources of ignition.
R 36/37/38 Irritating to eyes, respiratory system
and skin.
Safety Phrases:
S 9 Keep container in a well-ventilated place.
S 16 Keep away from sources of ignition - No
smoking.
S 23 Do not inhale gas/fumes/vapour/spray.
S 24/25 Avoid contact with skin and eyes.
S 26 In case of contact with eyes, rinse immediately
with plenty of water and seek medical advice.
S 33 Take precautionary measures against static
discharges.
S 36/37/39 Wear suitable protective clothing, gloves
and eye/face protection.
WGK (Water Danger/Protection)
CAS# 109-92-2: 1
Canada
CAS# 109-92-2 is listed on Canada's DSL List.
CAS# 109-92-2 is not listed on Canada's Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 109-92-2 is listed on the TSCA inventory.


SECTION 16 - ADDITIONAL INFORMATION
N/A

Home   |   Announcement   |   Partners   |   Business Cooperation   |   Suppliers   |   Products    |   About Us   |   Contact Us   |   Privacy Policy   |   Terms & Conditions   |   Legal Statement

Copyright © 2013-2016 MOLBASE All Rights Reserved ICP Shanghai 14014220